2001 Chevrolet Silverado Suspension Problems

UPPER A-FRAME/ CONTROL ARM ROTTED AWAY, PERFORATING AROUND BALL JOINT, ALLOWING BALL JOINT TO BREAK OFF VEHICLE. EXTENSIVE ROT ALL OVER VEHICLE UNDERSIDE FOR LAST 10 YEARS.

I BROUGHT MY 2001 CHEVY SILVERADO IN FOR IT'S ANNUAL INSPECTION, I WAS TOLD THAT THE TRUCK DID NOT PASS INSPECTION AS THE FRAME WAS ALL RUSTED OUT, THE REST OF THE TRUCK LOOKS LIKE IT IS ONLY A FEW YEARS OLD AND OTHER THAN THE REAR BUMPER, IT DOESN'T HAVE ANY RUST ON IT, AS I HAVE TAKE WELL CARE OF IT SINCE I PURCHASED IT NEW; A FEW YEARS BACK, I NEEDED TO GET ALL THE BREAK SENSORS REPLACED, HAD TO REPLACE ALL THE BREAK LINES, AND REPLACE 2 OF THE BRAKE ROTORS AND DISK, DUE TO RUST. WHEN I CHECKED AROUND FOR A NEW FRAME, I WAS TOLD THAT THIS IS VERY COMMON FOR GM TRUCKS BUILT AROUND 2001. I CANNOT AFFORD TO BUY A NEW TRUCK OR PAY THE APPROX. $7,000 COST OF PUTTING A NEW FRAME UNDER MY TRUCK. I THINK THAT DUE TO ALL THE PROBLEMS WITH THIS PARTICULAR MODEL YEAR, GM SHOULD ISSUE A RECALL TO REPLACE THE FRAMES, AND REIMBURSE. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERDO 1500. WHILE DRIVING AT 5 MPH AND WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT WHEEL BEARING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 100,000.

I HAVE TRIED TO STAY WITH A GM PRODUCT BUT THE TRUCK I RECENTLY PURCHASED HAD THE FOLLOWING PROBLEMS,WHILE TRYING ALSO TO AVOID THE MOST COMMON PROBLEM OF THE GM BAD FRAME,BY THE WAY TOYOTA WARRANTIES THERE FRAMES. THE 1ST MONTH OF OWNERSHIP THE REAR SPRING SHACKLES BROKE THERE ARE 30 YEAR OLD TRUCKS THAT STILL DON'T HAVE THIS PROBLEM,I OWN ONE. NEXT ABOUT ANOTHER 30 DAYS GO BY THE ELECTRIC FUEL PUMP DECIDED TO DIE. THAT SO FAR BRINGS REPAIRS UP TO CLOSE TO 650.00 AFTER 60 DAYS. LAST WK. MY BRAKE LINE FAILED @ ABOUT 50 MPH,NO WARNING LIGHT RIGHT TO THE FLOOR.THIS TRUCK HAD BEEN TAKEN CARE OF . SHOULD I CONTINUE ABOUT THE HOLE IN MY WINDSHIELD FRAME EVERY TIME IT RAINS MY ASH TRAY IS FILLED WITH WATER. BY THE WAY I WAS QUOTED ABOUT 1400.00 FOR ALL THE BRAKE LINE REPAIRS. WTF GM WHO HAS THAT KIND OF MONEY FOR REPAIRS,I DONT. THE PUBLIC SHOULD BE COMPENSATED FOR SUBSTANDARD MATERIAL USE. *TR

AFTER HITTING A BUMP IN THE ROAD THE RIGHT REAR LEAF SPRING MOUNTING BRACKET BROKE. AFTER FURTHER INVESTIGATION AT A LOCAL CHEVY DEALERSHIP IT WAS DISCOVERED THAT THE LEAF SPRING ITSELF WAS ALSO CRACKED. FURTHER INVESTIGATION REVEALED THE SAME TO BE TRUE ON THE LEFT SIDE OF THE TRUCK AS WELL. IT WAS ALSO DISCOVERED THAT THE RIGHT REAR SHOCK, WHERE IT ATTACHES TO THE FRAME, WAS COMPLETELY CORRODED OFF. IT WAS WHILE UNDER THE TRUCK INVESTIGATING THE SUSPENSION ISSUES THAT IT WAS DISCOVERED THAT THE ENTIRE BRAKE LINE SYSTEM WAS SEVERELY CORRODED. I FELT FORTUNATE THAT THIS WAS DISCOVERED BEFORE A CATASTROPHIC FAILURE OCCURRED. IT WAS ALSO NOTICED THAT THE ENTIRE UNDER CARRIAGE/FRAME WAS SEVERELY CORRODED. WHEN ASKED IF THIS WAS NORMAL, THE CHEVY MECHANIC STATED THAT THEY SEE THIS ALL THE TIME ON THE GM TRUCKS THEY SERVICE. ALTHOUGH THIS SURVEY IS FOR THE BRAKE LINES I FEEL THAT THE CORROSION ISSUES ASSOCIATED WITH THE FRAME IS JUST AS SEVERE AN ISSUE AND SHOULD BE INVESTIGATED. *TR

MY TRUCK HAS EXCESSIVE UNDERCARRIAGE RUST, TO THE POINT OF REDUCED MATERIAL THICKNESS ON THE FRAME AND ALL FRAME MOUNTED COMPONENTS. HAVE EXPERIENCE ONE FUEL LINE FAILURE AND FEAR ADDITIONAL FAILURES OF FUEL AND BRAKE LINES. ALSO ALL SUSPENSION MOUNTING POINTS HAVE LARGE METAL FLAKES COMING OFF. *TR

I WAS PULLING INTO PARKING SPACE AND THERE WAS NO BRAKES ALSO HAPPENED WHEN I WAS PULLING OUT OF PARKING LOT OF STORE .I TOOK TO GM DEALER AND WAS TOLD THAT BOTH HUB BEARINGS WERE LOOSE AND THAT IS WHAT CAUSED ME TO LOSE ALL MY BRAKES. I HIT A CONCRETE HANDICAP SIGN WAS LUCKY NOT ANOTHER CAR IN FRONT OF ME. WHY WOULD GM MAKE A TRUCK THAT WOULD LOSE ITS BRAKES IF A BEARING WAS LOOSE I AM AFRAID TO DRIVE TRUCK THAT THE SAME THING MIGHT HAPPEN AGAIN AND MAYBE THE NEXT TIME I WON'T BE SO LUCKY. THERE WAS NO SIGN OF ANYTHING WRONG WITH THE EXCEPTION OF 4 DAYS EARLIER MY ABS LIGHT FLICKERED ON THEN OFF 1 TIME. REMAINED OFF AFTER THAT. *TR

I WAS DRIVING TO ALABAMA FROM FLORIDA. WHEN I WAS ABOUT THREE HOURS OUT I WAS GOING DOWN THE ROAD HAULING A LOT OF PERSONAL ITEMS SINCE I WAS IN THE MIDDLE OF MOVING. IT STARTED STORMING REAL BAD SO I SLOWED DOWN TO 60 MPH AND AS I WAS APPROACHING ANOTHER VEHICLE THEY ALL THE SUDDEN SLAMMED ON THEIR BRAKES. I SAW THEM AS SOON AS THEY DID IT THEN I SLAMMED ON MY BRAKES AND THE PEDAL WENT STRAIGHT TO THE FLOOR. I ALMOST HIT THEM BUT I TURNED SHARP AND WENT INTO THE WOODS. I DIDN'T HIT ANYTHING BUT SMALL TREES SO VERY LITTLE DAMAGE TO OUTSIDE OF TRUCK. DAMAGE IS STILL THEIR BECAUSE SINCE THE WRECK I HAVE NOT BEEN ABLE TO WORK CAUSE I DESTROYED MY BACK AND NECK. AFTER THAT I STILL HAD TO DRIVE THE TRUCK THE REST OF THE THREE HOUR TRIP THAT ENDED UP TAKING NINE HOURS OF EXTREME PAIN AND SHOT NERVES. ONCE I FINALLY GOT HOME IT TOOK FOREVER AND A LOT OF MONEY TO HALF WAY FIX THE TRUCK. SINCE YOU CAN'T GET REPLACEMENT LINES AND HAD TO HAVE THEM CUSTOM MADE. TRUCK IS STILL CRAP BECAUSE NOW EVERY SINGLE PART OF THE BRAKE SYSTEM IS SHOT ALONG WITH THE BODY AND UNDERCARRIAGE. IT IS SOLID RUST NOW AND KEEPS BRAKING DOWN AND WILL COST AROUND THREE TO FIVE THOUSAND AT THE CHEAPEST TO FIX. IF I WOULD HAVE KNOWN WHAT I DO NOW THEN I WOULD HAVE SUED CHEVY AND THIS WORTHLESS ORGANIZATION CAUSE YALL HAVE KNOWN ABOUT THIS PROBLEM FOR A LONG TIME AND DID NOTHING. I THINK YALL AND CHEVY OWE ME AND THOUSANDS OF OTHER PEOPLE A LOT OF MONEY. IF YOU STILL DO NOTHING I WILL GO TO EVERY NEWS ORGANIZATION OR ANY OTHER COMPANY OR LAWYER THAT WILL GO AFTER YOUR COMPANY. YOU ARE HERE TO PROTECT PEOPLE FROM THINGS LIKE THIS BUT ALL YOU HAVE DONE IS HOPE WE ALL DIE. I WILL SPEND THE REST OF MY LIFE TRYING TO SHUT YOU DOWN AND MAKE EVERY PERSON THAT WORKS FOR THIS CRAP ORGANIZATION RESPONSIBLE FOR EVERY PERSON THAT GETS HURT OR DIES. JUST DO YOUR JOB THAT'S ALL I WANT.

MY DRIVERS SIDE HUB WENT OUT ABOUT 120,000 MILES. REPLACED IT, WENT OUT LESS THAN OVER YEAR LATER, THEN AGAIN LESS THAN 6 MONTHS LATER . TAILGATE LATCH BROKE BEFORE THEN, ABOUT ONE YEAR LATER, FUEL PUMP WENT OUT. FRONT RUNNING LIGHTS ALWAYS SEEM TO HAVE A LIGHT OUT. 2009 RACK AND PINION WENT OUT, REPLACED IT, THEN ONE YEAR LATER WENT OUT AGAIN.U JOINT WENT OUT ABOUT SAME TIME. AND IGNITION STUCK AND COULDN'T TAKE OUT OF GEAR OR TURN OFF. FUEL LINE UNCLIPPED AND DUMPED ALL MY GAS,2010 TRANSMISSION WENT OUT. NOW MY PASSENGER SIDE HUB ASSEMBLY HAS GONE OUT FOR FIRST TIME WITH ABS LIGHT ON AND WHEEL CLANKING AND SEPARATING. RACK AND PINION BLOWN ALSO. REPAIRS NOT CHEAP, AND ALWAYS HAPPENS AT FINANCIALLY BAD TIME. SO NOW IT SITS IN DRIVEWAY BROKE DOWN AND I'M TRYING TO FIND A HUB FOR CHEAP SO I CAN GET AROUND AGAIN TO WORK ETC. SEEMS LIKE EVERYTIME I FIX SOMETHING ANOTHER PART GOES OUT. NEVER HEARD ABOUT ANY RECALL PROBLEMS TILL NOW, AND WOULD LIKE TO KNOW ABOUT ANY OPTIONS OF GETTING REPAIR. ITS COSTING ME WEEKS OF OFF TIME FROM WORK. AND BILLS PILING UP, RENT PAST DUE, NO MONEY TO REPAIR, AND AFFECTING MY COULD'VE LIFE. ANY HELP APPRECIATED. I LIKE CHEVY, BUY JUST FEEL LIKE MINE SEEMS TO HAVE ALLOT OF PROBLEMS THAT HAS BEEN DESCRIBED IN YOUR PAGE I READ. IN FACT HAD EVERY PROBLEM LISTED PLUS .PLEASE HELP IF YOU CAN. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

1. NO WARNING 2. ABS KICK IN AT LOW SPEED AND LITTLE TO NO BRAKING IS RESULT IN FORWARD AND REVERSE, INCONSISTENTLY OCCURRING 3. DEALER REPLACED FRONT HUB #15233111 *TR

LEFT FRONT WHEEL BEARING FAILED WITH ONLY 76000 MILES ON VEHICLE. *JB

TL*THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 2500 HD. THE VEHICLE HAD JUST BEEN INSPECTED BY THE DEALER. WHILE DRIVING 55 MPH, THE CONTACT NOTICED THAT THE FRONT WHEELS BEGAN TO DETACH FROM THE VEHICLE DUE TO THE HUB AND WHEEL BEARING FAILING. THE DEALER STATED THAT NOTHING COULD BE DONE. THE CONTACT DOES NOT FEEL SAFE DRIVING THE VEHICLE BECAUSE HE TRAVELS DOWN A STEEP 600 FOOT HILL AND FEARS A CRASH COULD OCCUR. THE CURRENT MILEAGE WAS 100,000 AND FAILURE MILEAGE WAS 76,000.

WELD ATTACHING RIGHT UPPER CONTROL ARM MOUNTS TO FRAME CRACKED COMPLETELY THROUGH. I AM ORIGINAL OWNER. VEHICLE NEVER IN CRASH OR MODIFIED IN ANY WAY. DISCOVERED WHILE SEARCHING FOR CAUSE OF SUDDEN PLAY IN STEERING. NOT YET REPAIRED. THIS DEFECT COULD LEAD TO COMPLETE FAILURE OF RIGHT FRONT SUSPENSION AND STEERING. *NM

THE OWNER COMPLAINED ABOUT A BRAKE PROBLEM. WHEN APPLYING THE BRAKES THEY HARDENED, AND THE VEHICLE WOULD NOT STOP. ALSO THE OWNER CHANGED THE BRAKE PADS, ROTORS, AND BLED THE BRAKES. CURRENTLY, THE VEHICLE STILL DOESN'T HAVE MUCH BRAKING POWER. *AK THE PROBLEM WAS FOUND TO BE THE RIGHT FRONT BEARING AND THE HUB SENSOR. *SC *JB

CONSUMER HEARD A POPPING SOUND FROM THE FRONT OF THE VEHICLE WHEN TURNING EITHER LEFT OR RIGHT. CONSUMER TOOK THE VEHICLE TO THE DEALER, AND MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *AK

2001 CHEVROLET SILVERADO HAS HAD A HISTORY OF PROBLEMS. *MR THE FUEL PUMP WAS REPLACED AND WAS DIAGNOSED BY K-S FUEL INJECTION AS BEING THE CAUSE OF THE ENGINE LIGHTS AND LOW POWER, THE WAS A FUEL LEAK IN WHICH THE REAR HOUSING WAS CRACKED AND LEAKING OIL, THE TRANSFER CASE AND THE DRIVESHAFTS WERE REMOVED, THE FRONT WHEEL BEARING WAS NOISY AND WAS REPLACED, THE UPPER BALL JOINT WAS BAD, AND A FAULTY "NSDU" SWITCH WAS REPLACED. *SC

WHILE DRIVING CONSUMER STATED THAT THE FRONT END WAS CAUSING THE STEERING TO PULL TO THE RIGHT. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

2001 CHEVY 2500 HD TRUCKS ( FRONT WHEEL HUB ASSEMBLIES) LOOSING UP UNDER NORMAL DRIVING CONDITIONS. THESE ARE SEALED HUB UNITS SO YOU MUST PURCHASE BRAND NEW ONES AT A COST OF OVER $500-700 PER UNIT. I HAVE HAD BOTH SIDES LOSING UP ON ME AND NOW THE REPLACEMENT IS NOW LOOSE AGAIN AFTER 30,000 MILES. TO TEST THIS YOU MUST JACK THE WHEEL OFF THE GROUND AND PUSH/PULL ON THE WHEEL IT WILL ROCK BACK AND FORTH AS IF ITS READY TO COME OFF THE WHEEL ASSEMBLY. I WAS A MECHANIC FOR 9 YEARS SO IM NOT YOUR AVERAGE DRIVER WHO WOULD NOT NOTICE ITEMS SUCH AS THIS. I TAKE BETTER CARE THAN MOST FOR MY TRUCKS AND SEE THIS AS A MAJOR SAFETY FACTOR FOR ALL OTHER CHEVY TRUCKS ON THE ROAD. NOTE: THIS WAS AN EXPERIMENTAL HUB THEY USED FOR ONLY A COUPLE OF YEARS. NOW THEY WENT BACK TO THE ACTUAL BEARING NUT THAT YOU CAN TIGHTEN IF LOOSE....SEEM STRANGE HUH? MAYBE THEY KNOW SOMETHING AND TRIED TO KEEP IT UNDER THE TABLE??? *NM

WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE STARTED TO SHAKE SEVERELY WHICH MADE IT DIFFICULT TO CONTROL THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP AND THE CONSUMER WAS INFORMED BY THE MECHANIC THAT ALL FOUR(4) TIRES WERE OUT OF ROUND AND WOULD NEED TO BE REPLACED. *NLM

A NOISE COMING FROM THE FRONT END OF THE TRUCK. SOUNDS LIKE SOMETHING IS RUBBING WHEN MOVING. *AK