2006 Chrysler 300

The contact owns a 2006 Chrysler 300. The contact stated that while driving at undisclosed speeds, the vehicle shut off unexpectedly. The contact stated that the vehicle sputtered and stalled after refueling. There was an abnormal rumbling sound coming from the vehicle. The contact waited for 30 minutes to restart the vehicle. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. While driving and making a turn, the vehicle stalled. There were unknown warning lights illuminated. The contact associated the failure with NHTSA Campaign Number: 14V002000 (Fuel System, Gasoline). The local dealer was contacted and informed the contact that the vehicle could not be repaired. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.

Completed x53 extended warranty a year prior at dealership, car still stalls only after putting fuel even though always filling to 3/4-7/8 of tank. Had my children with me Car stalled again today at middle of busy street when about to make a left turn after i filled to 3/4 of a tank. Had dodge dealer in Manteca, CA diagnose after first stall half a year prior and they would not replace faulty new tank. Still had to pay diagnostic fee saying fuel liquid was getting into vapor lines and flooding engine and that new tank is not the issue even though it is allowing fuel liquid to pass through vent valve which caused saturation of vapor canister and purge solenoid and engine stalling. Car only stalls when pumping gas 3/4 tank or above

I have had issues with fueling the vehicle as when I fuel it I am only able to get a few cents in at a time before the gas pump clicks off or gas starts coming out of the fuel filler neck itself. At most I have been able to fill up my tank halfway but when I try to fill it a few cents worth of gas above halfway, I have engine stalling issues. To try to solve this issue I replaced all the external fuel vapor parts (charcoal cannister, EGR valve, PCV valve, purge solenoid, gas cap, and leak detection pump). The issue is clearly a problem with the internal components of the fuel tank itself. Chrysler has a X53 lifetime warranty for my type of vehicle but only for 19 gallon fuel tanks and my car has an 18 gallon tank. However, NHTSA investigation PE13-016 has shown that the defect (a swollen vent valve) affects both sizes of tanks. Chrysler said that the X53 lifetime warranty on the defective tank is VIN specific and would not cover my vehicle because it has a 18 gallon tank. Now my vehicle dashboard is saying that the gas cap is leaking but the gas cap was just replaced thus this further points to a pressure issue within the tank. Chrysler dealerships will not help me and contacting FCA resulted in them just telling me to contact a dealer to check if the warranty is available for me.

The contact owns a 2006 Chrysler 300C. The contact received notifications of NHTSA Campaign Numbers: 15V313000 (AIR BAGS) and 16V352000 (AIR BAGS); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

After Fueling on several occasions the vehicle just abruptly stalls out and it's very dangerous I notice that there is recalls on other 2006 Chrysler but mine isn't on there but I am very concerned about this as it could cause me to get in a accident

car stalled after filling gas tank. I was driving through an intersection and had to stop for oncoming traffic, when the car stalled and would not immediately restart, it eventually did start after several panic moments of being stuck in the intersection while the light was changing to let opposite traffic proceed. It stalled 2 more times on the way home. Both times I was slowing the car down when this occurred. I have been fearful of driving this car again since this happened. I heard there was a recall from Chrysler for lifetime replacement of gas tank due to a possible control valve shutoff float failure. My vehicle has never had the gas tank or float replaced, but it does not show up for a recall when I enter VIN. What should I do?

There a problem with car stalling and dying because of power being lost to tcm because of tipm. Dealer had my car for 7 weeks and $1900 changing tcm and problems still exist. Didn't even make 10 miles from dealership. Very dangerous

gasket around fuel pump failed allowing gas to pool on top of fuel tank under the back seat on passenger side . this resulted in a strong "gas/fuel" smell from fuel vapors colecting inside the car and the obvious risk of ignition/explosion and negative health effects of breathing said fumes .the vehicle has not been inspected yet because we are afraid to start the vehicle let alone drive it to the shop . We are making araingements to have it towed to the repair shop . we have not had any warning lights . Mechanic said it was a common problem with seal failure around fuel pump . the vehicle has 127,000 miles

Car will buck/jerk at higher speeds, will also die at low speeds or idle, will fall on its face when trying full throttle, the oil light, check engine light, Limp mode will flash sometimes traction control, esp will flash most the time the 2 lights stay on Problem has been confirmed by 2 dealers. Puts my saftry at risk because engine will js die at 20mph i lose brakes and steering. Problem first appeared about the beginning of this year when my camshaft went out but wasn't showing a code for a month and a half then gave me a code since then ive had this problem Vehicle has not been inspected

2006 Chrysler 300 Touring 3.5L V6 engine. Car has intermittent stall at slow speeds or at complete stop. Sometimes feels like it stumbles, other times it dies suddenly and unable to tell the engine shut down. I have to put car in park and completely switch the ignition fully off and turn back on to start position. When it stalls while rolling, I have to brake and bring car to full stop, with no power steering, and go through the same start procedure. No trouble codes are generated, and no check engine light indicator illuminated. Car usually starts right up, but sometimes I have to keep cranking starter, stumbles to catch as if starving for fuel. A/C was on first two times but also happens with A/C off. Research online reveals an open recall for the fuel tank on the 300C model with a 5.7L or 6.4L engine. Problems described on the 300C model are nearly identical to what my 300 Touring is experiencing. PCM replacement does not correct problem. Some noticed it happening only with a full tank. Stopgap measure is to only fill no more than 3/4 tank. I am currently testing this idea. The safety issue is significant and twofold; three times I have had one other adult and two children in the car. While stalled at a major intersection traffic signal trying to restart the engine, other vehicles approached from the rear at 50-55 MPH. A rear end collision with children in the back seat would likely be fatal. Secondly, during a stall event while the car is moving, it is extremely difficult to steer the vehicle to a safe place, and braking takes significant pedal pressure once power assist bleeds off. This is a serious concern and obvious collision hazard, as I may not be able to stop or steer to a safe location or avoid a hazard. I had the car at the dealer for over three weeks in July 2024 and they were unable to duplicate the issue. Their answer was to drive car until it happens more frequently. This is unacceptable. No other solution or repair was provided.

The contact owns a 2006 Chrysler 300. The contact stated while driving approximately 35 MPH, the vehicle started losing motive power. The contact stated there was smoke coming from under the hood. The contact stated no warning light was illuminated. The contact pulled over and observed that the temperature gauge indicated that the engine was HOT. The contact turned the vehicle off and waited for about 30 minutes and the vehicle restarted after several attempts. The contact had taken the vehicle to an independent mechanic where it was diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 133,000.

There is a fuel leak coming from the rear right side near the right rear wheel. Fuel leaks when the tank is full.

While I was driving the car, the car stalled on me at a stop light, its a safety risk and could caused an accident at anytime, yes its available for inspection. Yes the problem has been reported and inspected by auto shop and dealership. No warning lights it just randomly happened while driving, while I was driving the check engine light popped up then disappeared and 2mintues later my car power was reduced and car shutoff at stoplight.

The contact owns a 2006 Chrysler 300C. The contact stated that the fuel tank was previously replaced under an unknown extended warranty coverage; however, after the repair, the vehicle experienced a failure. The contact stated that after refueling the vehicle and driving at slow speeds, the vehicle stalled. The contact stated that the failure recurred several times while driving and coming to a complete stop. The vehicle was towed each time the failure occurred. The contact stated that the vehicle stalled in the middle of the road during the last failure. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and test-driven, but the cause of the failure could not be determined. The vehicle was not repaired. The failure mileage was approximately 214,624.

While driving at speed limit car dash lights all light up and car stops running. You loose steering, brakes all electrical lights. Car may restart and power restored and if not must stop car if possible to restart. Happens randomly! This is a continued problem. Has happened more than 10 times and seems to be having this problem more and more often. No one knows how to fix problem.

Once fueled, the engine will consistently stall from start to cruising speed, and has even shut off while driving. There was an issue with Chrysler fuel tanks evap valve sticking open, which causes this fault, however I have not received any assistance from Chrysler or any authorized dealer.

My Fuel Tank is stuck in open position, it is making my car stall, sputter, and cut off. When my gas is very low car doesn't cut off and runs fine, but when I fill car up it stalls and cuts off, this is very dangerous it cuts off at red lights, stop signs, slow traffic, I've seen this is a Warranty/Recall problem with the faulty fuel tanks, with stuck open fuel shutoff valve. My car is running at max fuel because of this problem. It's been like this since I bought car 2 months ago. I need this fixed immediately. And all parts on my car are brand new this Faulty fuel tank is the Culprit

The contact owns a 2006 Chrysler 300C. The contact stated that while driving at slow speeds during traffic congestion, the vehicle inadvertently lost motive power and stalled. Upon restarting the vehicle, the vehicle hesitated but seemed to return to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 200,000.

The car will just shut off while driving or at rest. My safety and other people on the road is unsafe in the vehicle because when it shuts off in the middle of the road the steering wheel is also not working. The car has been to multiple shops with each shop guessing what could be the problem and fixing what they think may be wrong and after 2,000 dollars the car is still stalling out while being drove. No lights or diagnostic test come up with anything that could cause the problem

While driving my Chrysler when I stop at a red light or stop sign the car will simply stall out and die so I put it back in park and recrank it and sometimes it'll die immediately after that and sometimes it'll wait till the next red light or until I'm making next stop. And when the car is in park it'll stall out I'll simply have to crank it right back up sometimes it'll stall out immediately after that and sometimes it'll run for a minute or two and then stall out. But as long as I got my gas my foot on the gas while I'm breaking at the same time it won't die